Re: 1988 cherkoee cigarette lighter issues

Matt wrote:
> On Feb 27, 9:44 am, Mike Romain <roma...@[EMAIL PROTECTED]
> wrote:
>> Matt wrote:
>>> here's an interesting twist on all of this - been using just the cig
>>> lighter adapater for now, since its still too cold for me to spend a
>>> ton of time outside taking the dash apart to run all these wires...and
>>> it's been working fine.
>>> tonight, i come out of the bar after dinner, and the cig lighter and
>>> radio both won't turn on.  i think, ok i blew the fuse...i have the
>>> fuses with me (keep a set in the jeep all the time now), so i turn the
>>> car off to get ready to replace the fuse.  just for ****s and giggles
>>> (and i have no idea what made me think of this), i turn the key back
>>> to acc...voila, radio and cig lighter power up.  turn the jeep back on
>>> - radio and cig lighter power up.
>>> what could cause this?  i found it very odd...keep in mind, it has
>>> been working perfectly for the past 2-3 weeks...
>> Cold weather and worn linkage parts are my first thought.
>>
>> The ignition switch itself is adjustable and is hooked to the key
switch
>> via metal rods.  With wear on the parts and cold weather making grease
>> stiff, it might be 'just' at the edge of making a good connection every
>> time.
>>
>> The switch is down the bottom of the column at the top and has slotted
>> holes to adjust it.
>>
>> The switches also just wear out.  It is a very common Saginaw steering
>> column, the same as GM use on the full sized vans and lots of cars like
>> Camaros, etc...  Junk yards should have a good supply of them.
>>
>> Mike
>> 86/00 CJ7 Laredo, 33x9.5 BFG Muds, 'glass nose to tail in '00
>> 'New' frame in the works for '08.  Some Canadian Bush Trip and Build
>> Photos:http://mikeromainjeeptrips.shutterfly.com
> 
> so i should replace the ignition switch?  where exactly should i
> start?  how difficult a job is this?

I would try to adjust it to make up for wear before replacing it and 
then if it still had dead spots replace it.

It is on the top of the column at the bottom.

Mike